There's a couple of different ways to prepare these– leave them whole or cut them in half.
Personally, I like them cut in half but you can try them both ways and see how you like them.
Regardless of whole or half, you do the initial prep the same so let's get started.
Wash the peppers
Remove the handle (stem)
Remove the seeds and veins
I usually do this with a small paring knife but I just recently purchased a special tool for this at the local hardware store and it works pretty good. Here's a similar one on Amazon if you want to see it.
If you know that you are planning to cut them in half and you don't have a special tool for coring out the peppers, you can cut them in half first then remove the seeds and veins if that's easier for you.
You have to find your own mojo on these and it will get better with a little practice.
Trust me.. by the time you do 30 of these, you'll be quite the expert.
At this point you probably need to fully decide if you want to leave them whole or cut them in half.
Here are the 9 peppers that I left whole.. sitting in a pepper holder that came with my jalapeño corer:
And then here's the 43 boats that I made by cutting 21 of the peppers in half.
I have no idea how I ended up with an extra.. maybe I actually started with 22 and dropped one of the halves?
This cream cheese mixture is the bomb and it's so good you may be tempted to lick the spoon.. I also had this problem.
As long as you know that if you lick the spoon too much, you may not have enough to fill all of the peppers 😉
I try to figure on 8 oz of cream cheese, 1 cup of shredded cheese and ¼ cup of my original rub (Purchase formula here | Purchase bottled rub) per 12-15 whole peppers or 24-30 half peppers.
I purchased around 30 peppers so I decided to make a double batch of the mixture with the following ingredients:
Mix it all up with a fork or whatever utensil works for you.
Lick the mixing utensil.. it'd be a shame to waste it!
Now we are ready for my favorite part, stuffing the peppers with this delicious mixture =)
There's no right or wrong way to do this.. just use a spoon to get the mixture into the whole peppers or into the half pepper boats.
1 slice per whole pepper or half slices for the half pepper boats works best for me.
I purchased 3 lbs of bacon and used just slightly over 2 lbs.
Wrap the bacon around the pepper and try to figure it so it ends up finishing on the bottom of the pepper. In this way, the pepper sits on the end of the bacon and no toothpick is required to hold it in place.
I stopped using toothpicks several years ago and never looked back.. just not really necessary in my opinion.
Here's the whole peppers wrapped in bacon:
And the boats all wrapped up:
Give them another sprinkle of my original rub (Purchase formula here | Purchase bottled rub) and they are ready for the smoker.
About the smoker..
For these wonderful smoked stuffed jalapeños appetizers I used the new Bradley Smart Smoker.. it's a good smoker and perfect for so many applications.
One of the things that we talked about in the last newsletter (the one with questions and answers) is how to get more smoke in electric smokers. Some electric smokers have trouble producing smoke due to the heating element cycling on and off and to make the chips and chunks smolder and produce smoke, you need constant heat really.
This is where the Bradley really shines.. it has it's own low wattage heat plate that produces constant heat. The bisquettes move onto the heat plate and this constant heat has been calibrated perfectly so that it causes the wood to smolder but not ignite. Heck, you can even run the smaller heat plate to produce smoke and leave the main heating element turned off.. I'm thinking smoked cheese baby!
I got the Bradley set up with enough maple bisquettes for 2 hours of smoke and 3 hours of cooking time at 230°F which is perfect for these ABT's.
Once the Bradley was hovering around 230°F, I put the Bradley racks filled with the prepared jalapeños into the smoker.
I also placed the pepper rack with the 9 whole peppers on one of the racks.
The door was closed and it was hands off for 3 hours while I waited for the peppers.
At exactly 3 hours I opened the door and removed the stuffed jalapeño peppers to the kitchen. As expected they were perfectly done and the flavor was amazing.
If you are not planning to eat these right away, put them into a foil pan covered with foil and into a oven at it's lowest setting (usually about 170°F) to keep them hot.
Serve and watch them disappear like magic!
Get some help
Solicit a few other people to help with this. If you set up an assembly line where someone is cutting stems, a couple of folks are coring and then someone is cutting them in half, etc. it's much easier.
I was an engineer (IE & ME) in a previous life so this appeals to me.. the person removing the stems could also be cutting them in half to balance out the work and reduce bottlenecks.
If you only have one other helper, perhaps one could remove the stem and core while the next person cuts them in half and stuffs. You could then work together to wrap with bacon.
As you can see, this can be engineered down to a well oiled machine..
Reduce the “hotness”
If jalapeños are just too hot for some, you can soak them in sprite or some other lemon lime soda for a couple of hours once the seeds and veins are removed. You can do this whole or in halves.. works great either way.
Some of the spiciness will leach out into the soda and the peppers will become more mild. The longer you soak, the more mild they become.
Save the soda to use when marinating chicken or some other meat.. it will give them a nice jalapeño flavor.
I know some of you are wondering.. I have no idea if you can use other types or flavors of soda. I heard about this trick several years ago and it worked so I figure if it's not broke…
Finding thin bacon
As I mentioned, anytime you are wrapping things in bacon for the smoker, thin bacon usually works best.
Bacon is usually not labeled as “thin” but what you can do is count the slices to see how thin it is. If you find a pound size package of bacon and it has 12-13 slices, it is cut fairly thin. The more pieces of bacon in the pound package, the thinner the bacon.