|

Smoked Burgers, Hotdogs and Brats

IMG 0040

Smoking-Meat.com is supported by its readers. We may earn an affiliate commission at no extra cost to you if you buy through a link on this page.

Read this article without ads

Throughout this summer, you will no doubt have numerous opportunities to smoke hamburgers, hotdogs, brats and even boudin or sausages. The smoker is the perfect way to cook these up perfectly and usually in less than 2 hours.

Helpful Information
  • Prep Time: 15 minutes
  • Cook Time: 1-2 hours
  • Smoker Temp: 240°F
  • Meat Finish Temp: 160°F
  • Recommended Wood: Pecan
What You’ll Need
  • Ground beef or chuck for burgers (80/20 or ), made into patties that are about 1/3 pound or whatever size you like
  • Assortment of hotdogs, sausages, brats and boudin
  • Jeff’s original rub
Preparing the Meat

Burgers

When you purchase the meat, I recommend going for ground beef with a high fat content.. I usually use 80/20, 78/22 or even 73/27 depending on what's available. The first number is the percentage of lean meat and the second number is the percentage of fat. Remember, more fat = more flavor.

Divide the meat up into portions of whatever size or weight that you like.. you can eyeball it or use a small kitchen scale.

Make the meat into patties and season each one with the Texas style rub  on the top and the bottom.

In addition to the outside of the burgers, you can also mix some of the Texas style rub  into the meat if you like. Use about 1 TBS per pound of meat.

Set aside.

Note: Another option for burgers is to stuff them and wrap them with bacon.. I did an article about this last year.

2015-IMG_7488

Hotdogs, Boudin, Brats and Sausages

Remove from the package and place into a bowl or container.

Set aside.

IMG_9995-250x167

If you want to add some of my original rub  to the hotdogs, it's very delicious!

Just put some of the rub on a flat surface and roll the hotdogs in the rub.

2014-IMG_3610

Another option for hotdogs is to spiral cut them.. it looks really cool and is incredibly easy to do. Check out my instructions for that here.

2012-IMG_5675

And then there's bacon wrapped hot links.. don't even get me started!

bacon-wrapped-hot-links-and-sausages-250x167

Setup the Smoker

I like to cook burgers and hotdogs at normal indirect smoking temperatures of about 225-240°F.

Have enough smoking wood for at least 1 hour of smoke but more than that is fine.

Make sure you use the water pan if your smoker is so equipped.

Once your smoker is preheated and up to temperature, it's ready to go.

Smoke the Meat

Place the brats, Boudin and sausages on the smoker first as these will usually take about an hour longer than burgers and hotdogs.

Smoke them for about 1 hour then place the hotdogs and burgers on the smoker grate.

I used a Weber grill pan to make it easy to transport the meat back and forth from the smoker to the kitchen. Bradley racks also work great if you have them.

About 20 minutes before the meat is done, brush some of my delicious barbecue sauce (Purchase formula here | Purchase bottled sauce) onto everything except the boudin if you like.. it's really good that way and the kids seem to love it especially well.

The boudin skin crisps up best if you just leave it alone, no sauce.

Crisp Up the Meat

Burgers, hotdogs etc. are really good when just done on the smoker but if you want to put a little crisp on the burgers, a little sizzle on the hotdogs, brats and sausages, then just move them to a grill preheated to high and ready to go about 20 minutes before they are due to be done.

I usually move them over to the hot grill before putting on the sauce. The high heat together with the sauce gives them a perfect finish.

Here's the cooking times/temperature that I recommend:

  • Burgers: 1 hour or 160°F in the center
  • Hotdogs: 1 hour or hot in the center and browned on the outside
  • Brats: 2 hours or 160°F in the center
  • Sausages: 2 hours or hot in the center and browned on the outside
  • Boudin: 2 hours or browned outside and crispy skin

Note: Be sure to use a digital remote meat thermometer like the Thermoworks “Smoke” or an accurate handheld thermometer like the Thermapen or the  ThermoPop on the burgers and brats to make sure they reach the perfect temperature without overcooking them.

And remember, if you need to get these done fast, there is nothing wrong with cranking up the temperature and just cooking them until they are the correct temperature or color.

IMG_0033-250x167

IMG_0036-250x167

Get Jeff’s Products!

Leave a Reply to Jeff Phillips Cancel reply

Your email address will not be published. Required fields are marked *

12 Comments

  1. I don’t have a smoker just a regular kettle grill, all I want to do is smoke both of them with charcoal and smoking wood chunks then get them a little crusty on outside. How do I do that

  2. Been enjoying your site for many years. You have been my number 1 source of information since I began smoking meat. Doing burgers and bacon and potato salad on the smoker for the 4th. I already did the cheese, lol. Keep up the good work. God Bless America!

    1. Norman, do you not like burgers, hotdogs and brats? Those items are very American and, if done correctly, they are some of my favorites. The smoker takes them to the next level ;-)

  3. 80/20 beef. You have it backwards. The first number is the percentage of lean meat. The second number is the percentage of fat.

  4. “When you purchase the meat, I recommend going for ground beef with a high fat content.. I usually use 80/20, 78/22 or even 73/27 depending on what’s available. The first number is the fat percentage and the second number is the percentage of lean meat. Remember, more fat = more flavor.”

    Pretty sure it’s the other way around. Lean/Fat. I do concur that more fat means more taste (and juiciness).

  5. Hi Jeff,

    Got your rubs an sause recipes a while back….the family loves the flavor it adds to everything. I use it on pretty much everything!!
    I’ve tryed several resipies of yours and ALL have been repeat requests, and a lot more I want to try.
    Thanks so much for your tips and techniques!!

  6. Tried my new smoker with Belly Pork Ribs and Tomahawk steaks went down a treat everybody enjoyed my first attempt and cant wait for a repeat they even took the remainder of the sauce home in pots as they thought it was so tasty.
    Mark from the UK.

  7. Hey,

    Tried your BBQ sauce on the burnt ends, was great. I was thinking about substituting some of the brown sugar with some maple syrup, any thoughts on conversion amounts. Keep up the great work!

    Greg